[In Vitro Studies on the Transfer of CAR into Leukemia Cells Due to Their Residue in the Autologous CAR-T Cell Preparation System for Acute B-cell Acute Lymphoblastic Leukemia]

To investigate the characteristics and cytotoxicity in vitro of the residual leukemia cells in the culture system that caused the accidental transfer of CD19 chimeric antigen receptor (CAR) into leukemia cells during the preparation of autologous CD19 CAR-T cells of relapsed/refractory B-cell acute lymphoblastic leukemia. ①Peripheral blood mononuclear cells (PBMC) of 30 patients with relapsed/refractory B-cell acute lymphoblastic anemia (R/R B-ALL) who accepted CD19 CAR-T cell therapy and six healthy volunteers were collected. ②The residual leukemia cells were analyzed by flow cytometry in the system after the PBMCs of R/R B-ALL patients were sorted by CD3 magnetic beads. ③ CD3(+) T cells from patients and healthy volunteers were transfected with CD19 CAR and CD22 CAR lentivirus to prepare CD19 CAR-T and CD22 CAR-T cells. ④The Nalm-6 cell line was resuscitated and the Nalm-6 cells with CD19 CAR lentivirus were transfected to prepare CD19 CAR-Nalm-6 cells. The patient's primary ALL cells were transfected with CD19 CAR lentivirus at the same time. ⑤The transfection rates were analyzed by flow cytometer, the cell proliferation was analyzed by the CCK-8 method, and the cell-killing activities were detected by the lactate dehydrogenase method. ① Among the 30 R/R B-ALL patients who received CD19 CAR-T cell therapy, two patients had 2.04% and 3.32% residual leukemia cells in CD3(+) T cells. After 4 days in culture, the residual leukemia cells disappeared and could not be detected by a flow cytometer with prolonged cultivation in vitro. ② The proliferation of CD19 CAR-Nalm-6 cells was higher than that of the Nalm-6 cells. ③ The killing activity of the CD19 CAR-T cells on Nalm-6 cells was higher than that of the CD19 CAR-Nalm6 cells at a target ratio of 1∶1 on 24, 48, 72 h, respectively. The cytotoxicity of CD22 CAR-T cells on CD19 CAR-Nalm-6 cells was significantly higher than that of CD19 CAR-T cells. ④ The cytotoxicity of CD22 CAR-T alone on CD19 CAR-Nalm-6 cells was higher than that of CD19 CAR-T combined with CD22 CAR-T at the same target ratio. The residual leukemia cells in the culture system in the preparation of CD19 CAR-T cells may lead to the introduction of CD19 CAR into leukemia cells and results in the failure of the CD19 CAR-T cell therapy. Detecting the residual leukemia cells in the culture system via flow cytometry before transfection with CD19 CAR lentivirus is needed. Thus, CD22 CAR-T cell therapy could be used as one of the salvage treatments.